Previously unseen government records detail ‘deeply worrying’ incidents in pork and poultry plants, raising fears of ‘dirty meat’ entering the UK under a post-Brexit trade deal
Shocking hygiene failings have been discovered in some of the US’s biggest meat plants, as a new analysis reveals that as many as 15% (one in seven) of the US population suffers from foodborne illnesses annually.
A joint investigation by the Bureau of Investigative Journalism (TBIJ) and the Guardian found that hygiene incidents are at numbers that experts described as “deeply worrying”.
US campaigners are calling once again for the closure of a legal loophole that allows meat with salmonella to be sold in the human supply chain, and also warn about the industry’s push to speed up production in the country’s meat plants. And UK campaigners warn that the UK could be flooded with “dirty meat” if a US trade deal is signed post-Brexit.
The unpublished US- government records highlight numerous specific incidents including:
All of the reported breaches resulted in immediate remedial action with no risk posed to consumers, according to the companies involved.
But campaigners warned that other violations may go undetected. Tony Corbo, senior lobbyist with Food and Water Watch, said: “While the inspectors are able to cite the plants for hundreds of violations per week, I am confident that they are not catching every instance of unsafe practices being committed in these plants.”
Meat hygiene inspectors interviewed by the Guardian agreed, saying fast line speeds and other pressures in some plants meant it was “inevitable” that some breaches slipped through the net.
The findings are worrying, according to Prof Erik Millstone, a food safety expert at Sussex University, “because of the risks of spreading infectious pathogens from carcass to carcass, and between portions of meat. The rates at which outbreaks of infectious food poisoning occur in the US are significantly higher than in the UK, or the EU, and poor hygiene in the meat supply chain is [a] leading cause of food poisoning in the US.”
The Bureau and the Guardian obtained previously unpublished documents relating to 47 meat plants across the US. Some of the documents relate to certain companies, including Pilgrim’s Pride, one of the US’s biggest poultry producers, and Swift Pork. Although not a comprehensive portrait of the sector – there are around 6,000 US plants regularly inspected by Food Safety and Inspection Service (FSIS) – the documents provide a snapshot of issues rarely detailed in public which has rung alarm bells with campaigners in both the US and UK.
“The US meat industry has a responsibility to clean up its act,” said David Wallinga, senior health officer at the Natural Resources Defence Council, which obtained some of the documents. He said the Pilgrim’s Pride records detailed “numerous food safety violations.”
Kerry McCarthy, former UK shadow environment minister and Labour MP, called for urgent reassurances from both the UK Food Standards Agency (FSA) and “the top of government” that standards would not be allowed to slip as trade negotiations with the US get underway.
“We cannot allow this to be a race to the bottom. We should insist the US raises its standards, and guarantees food safety, before we are prepared to allow in US meat imports,” she said. McCarthy has written to the environment secretary, Michael Gove, and Liam Fox, the trade secretary, to raise the matter.
The documents seen by the Bureau and Guardian do not reveal the full numbers of non-compliance reports across the whole sector. However, one dataset covering 13 large red meat and poultry plants over two years (2015-17) shows an average of more than 150 violations a week, and 15,000 violations over the entire period. Thousands of similar violations were recorded at 10 pork-producing plants over a five-year period up until 2016, further documents show.
Another batch of previously unpublished documents shows frequent failings at 24 plants operated by Pilgrim’s Pride who recently bought the British chicken giant Moy Park. The company slaughters 34 million birds each week and produces one in five of the chickens in the country.
More than 16,000 non-compliance reports on Pilgrim’s Pride operations detail 36,612 individual regulatory violations – an average of 1,464 a month – at the 24 plants during a 25-month period between 2014 and 2016.
In one incident, diseased meat – condemned from entering the human food chain – was placed in a container meant for edible product. An inspector discovered “carcasses of poultry showing evidence of septicemic disease … carcasses showing evidence of having died from other causes than slaughter … guts of carcasses, [and] poultry carcasses with heads attached.” He requested that the condemned items be removed. A similar incident was recorded some days later.
One inspector saw chicken drumsticks piling up on the floor, and instructed workers to pick them up “to be reconditioned with chlorinated water.” Again, a similar incident had occurred previously. In another incident in a bagging department, 36 shrink-wrapped whole birds were found scattered on the floor. An inspector noted: “in my presence the establishments began initiating their corrective action by picking up all affected product off the floor … to be carried to the establishment’s designated wash station to be thoroughly rinsed off.”
Meat soiled with faecal matter was also recorded, with an inspector noting “… I observed a poultry intestine in the liver bin. The intestine was approximately 6.5 inches long and had visible faeces oozing out both ends.” The incident resulted in the livers being condemned from the human food chain.
At another Pilgrim’s Pride plant, the records reveal how deficient equipment led to a carcass becoming contaminated with faeces. “I observed one of my 10 test birds with a spot of faecal matter on the exterior of the right thigh. The spot of faecal [sic] was … brownish green in colour and had a pasty consistency,” an inspector notes. The affected bird was “retained by management for review then sent to reprocessing for reconditioning with chlorinated water.” Similar carcass contamination had been recorded before.
Internal FSIS records also highlight numerous violations at meat plants producing pork. In an incident recorded at a plant run by Swift Pork, owned by meat giant JBS, 48 pig carcasses were found to have fallen on the floor because of defective equipment, leading to contamination with “black trolley grease, floor grime and bloody smears”. The records noted: “The line was stopped for about 15 minutes. The carcasses were sent to be trimmed first then steam vacuumed with 180F water.”
On another occasion, an employee cleaned the factory floor with meat products on an adjacent conveyor belt, creating a mist that could contaminate the meat. “This mist is contaminated by the inedible debris and … comes into contact with edible product,” an inspector observed.
In a separate incident, a pig’s head was found to have partially covered a drain, leading to “bloody waste water filling the area”. This and another blockage caused by a buildup of skin led to dirty water flooding other areas. “Because of the plugged drains, an insanitary condition was created; the bloody water in the walkway could be splashed and carried throughout the kill floor after employees walked through the puddle,” an inspector wrote.
In a different part of the factory, inspectors found a stainless steel handwash sink “plugged and approximately one-quarter full of standing bloody water with pieces of fat and meat. Production employees use this sink to clean and sanitise their hands and gloves. This creates an insanitary condition.”
In a statement, JBS, which owns Pilgrim’s and Swift Pork, said all of the violations recorded were “immediately addressed” and that consumers were never put at risk. “The US meat and poultry sector is one of the most highly regulated industries in America,” said Al Almanza, JBS’s global head of food safety and quality assurance, and former head of FSIS for 39 years. “Non-compliance reports are issued by USDA [United States Department of Agriculture] inspection personnel to document when an establishment has not met a specific regulatory requirement. However, the vast majority of non-compliance issues are addressed immediately and have no impact on food safety.”
“All of the documented incidents regarding JBS [Swift Pork] and Pilgrim’s were immediately addressed by our facilities. None of these incidents put anyone at risk or resulted in any adulterated product released into commerce. Food safety is achieved by implementing processes that consistently detect and correct issues before products are released into commerce. Our team at JBS and Pilgrim’s is committed to the highest food safety standards and we partner with USDA each and every day to ensure that consumers can enjoy safe and quality products with confidence.”
Salmonella and other foodborne illnesses
The US has shockingly high levels of foodborne illness, according to a new analysis by UK pressure group Sustain. It says that annually, around 14.7% (48 million people) of the US population is estimated to suffer from an illness, compared to around 1.5% (1 million) in the UK. In the US, 128,000 are hospitalised, and 3,000 die each year of foodborne diseases.The US has shockingly high levels of foodborne illness, according to a new analysis by UK pressure group Sustain. It says that annually, around 14.7% (48 million people) of the US population is estimated to suffer from an illness, compared to around 1.5% (1 million) in the UK. In the US, 128,000 are hospitalised, and 3,000 die each year of foodborne diseases.
One bug, salmonella, causes around 1m illnesses per year in the US, while in the UK the numbers of officially recorded incidents is relatively low, with just under 10,000 laboratory confirmed cases in 2016. However, unreported incidents could substantially increase those numbers. Salmonella takes hold on farms and is found in the guts of poultry and livestock: farm animals and birds can become contaminated with faeces containing the bacteria during transport to abattoirs, where slaughter and processing procedures can also spread it.
Kath Dalmeny, chief executive of Sustain, said the figures underscored concerns about future US-UK trade deals: “The US has already warned us that we will need to lower our food standards in exchange for a quick trade deal, but we need to fight this hard. They are desperate to sell us their chlorine-washed chicken, but we know chlorine and other unpalatable treatments can mask dirty meat, low hygiene standards and poor animal welfare, which the UK consumer will not stand for.
“In recent years, the UK meat, dairy and egg industries have improved food safety; so we should all be alarmed about any trade deal that opens up our market to products that undermine this progress.